MONTHLY REPORT 1 DECEMBER - 31 DECEMBER 1958 INSTALLATION AND MAINTENANCE BRANCH ENGINEERING STAFF
Document Type:
Collection:
Document Number (FOIA) /ESDN (CREST):
CIA-RDP78-02820A000400040046-3
Release Decision:
RIPPUB
Original Classification:
S
Document Page Count:
9
Document Creation Date:
December 9, 2016
Document Release Date:
August 3, 2000
Sequence Number:
46
Case Number:
Publication Date:
December 31, 1958
Content Type:
PERRPT
File:
Attachment | Size |
---|---|
![]() | 412.72 KB |
Body:
Approved For el- ki DP78-02820A000400040046-3
Now"
MONTHLY REPORT
1 DECEMB3*R - 31 DECEMBR 1958
INSTALLATION AND MAINTENANCE BRANCH
ENGINEERING STAFF
1. A Motorola 250 watt base station has been installed to replace
it
the 60 watt unit located in Room 2, East building. TThe 60~watt un
Warehouse, where it will be modified for repeater operation and installed
2. Eight men returned from schools, that included the AS4-A, KW-26,
and Flexowriter. A Flexowriter familiarization course has been started
in the Wire Shop at Curie Hall. All wire technicians processing for
overseas assignments will be briefed on Flexowriter operation. Fifteen
man-weeks have been spent on the Flexowriter program to the present
date.
3. Specifications and drawings are being prepared for a standard
KW-26 rack installation. After the fabrication and acceptance of the
prototype model, a brochure will be made up for distribution to all
areas.
4. Two new Electronic Technicians and one Wire Technician reported
on duty during this reporting period. Four men departed for overseas
assignments and eleven men are in process for overseas positions.
Chief, Installation an nee Branch, OC-E
Approved For Release 2002/05/01 : CIA-RDP78-02820A000400040046-3
Approved For Release 2002/0J
-RDP78-0282OA00Q 0040046-3
I WIRE MAIMENANCE -SECT
A. Trouble Reports
1. The Wire Maintenance Shops in the Washington area have
reported a total of two hundred and forty nine (2149) troubles
for the month of December. The troubles as broken down for
the different locations are as follows:
Signal Center
200
1717 "H" Street
15
OCI
24
Outside Area
10
2. This total shows an increase of nineteen (19) troubles
over last month. The Signal Center had a considerable
amount of 131-B2 table troubles this month which resulted
in this marked increase.
13. Daily Activities
1. The 0 teletype circuit GT-7085 was replaced by
teletype circuit G!2-7420. This circuit was checked out at
the three local signal centers and between each of these
signal centers to the
2. Due to the unfamiliarity of the 0 equipment by our
technicians in this area, troubles that developed have
taken considerable time to repair. Mechanical and electrical
adjustments seem to be very critical.
3. During the first part of the month, troubles on the KW-26
equipments ran quite high. Two core boards were found bad
and several tubes needed replacing. Tubes in all units were
checked in a tube checker, with bad tubes being replaced.
This resulted in numerous troubles appearing shortly after
placing units back in operation. It has been decided that
unless troubles develop , all tube and core board servicing
will be done by means of the marginal check method,
4. A Dial Door Lock was installed on the watch officer's
door "Q" Building as per request, Chief, OCI.
Approved For Release 2002/05/019P78-0282OA000400.04494 -3
Approved For Release 2002/05/01
P78-02820A000400040046-3
5. The maintenance shop for "Q" Building Signal Center is
nearly completed. All parts have been stored and location
cards have been made. The test bench is in place and is
in the process of being wired-up. The only other item still
necessary for completion is the rack shelving, which should
be delivered during January.
6. One man has returned from a six week course at the Flexo-
writer School in New York. Four men comp leted an eleven
week course at the on the KW-26.
7. Three men received instruction on the repair and main-
tenance of the Plexowriter. This course lasted one week.
The unit was stripped down and the operation and adjust-
ments were explained. Two weeks is normally the time needed
to complete this course. From the above, it can be-seen
that very little time was expended on the theory of operation
and this instruction does not constitute a thorough knowledge
of these equipments.
8. A Modell was delivered to "I" B ildin Signal Center for
25X1C4a use on the It is being
used as a monitor for additional copies. This was done to
comply with a written request from the Signal Center.
9. One ASR unit and two Model 28 Reperforators were delivered
to Room 544 "H" Street. These were installed and checked out
25X1C4a for use on the which will be operating at an
increased speed of one hundred words per minute. We are now
waiting for notification from the l to switch over.
10. We are able to keep two men most of the month at the
-~ As a result much work was completed.
Eight M-15 Consoles and one M-15 were cleaned, overhauled
and been P.T.I.'d in Class 1 condition.
The following work orders were completed for the T&I
Section:
a. Serviced the 6-ST van.
b. Repaired three M-19 Reperforators.
c. Checked out numerous equipments for overseas shipment.
11. The Secure vault at the now 25X1A6d
ready for use. Safemasters Lock Co. installed a combination
lock. Security inspected and approved the vault. The
combination was set,
Approved For Release 2002/0 WRT RDP78-0282OA000400040046-3
Approved For Release 2002/05/Q P78-0282OA000400040046-3
12. A space in the warehouse of approximately 12 feet by
25 feet was procured for storing
transient equipment for
the Rehab. Shop.
C. Special Projects
1. Listed below are projects that have started, but not
completed.
a. The overhaul of twenty major pieces of
equipment now at our Rehab. Shop.
b, Makin; drawings for the rack mounted KW-26's
using conduit and circuit breakers,
II ELECTRONIC MAINTENANCE SECTION
A. Microwave
1. Regular maintenance visits were made to both microwave
installations and minor defects noted were repaired.
2. One trouble call was received on the microwave system.
A defective subcarrier receiver was discovered at
3. Because of the work load we were unable to complete the
reconditioning of the microwave equipment at the Installation
and Maintenance Branch Shop,
B. Washington Disaster Plan
1. Regular maintenance visits were made to
and to Room 2. No cars of the Security Office V.H.F.
were,serviced this month.
2. No trouble calls were received for this period.
3. We have installed the Motorola 250 watt base station in
Room 2 of East Building. The equipment is operating as
expected, with the exception of a slight degradation of the
165.825 MC receiver when automatically retransmitting on
172.575 MC. We have requested that Motorola give us the
exact cable lengths between the cavity, transmitter,
receiver and antenna. This information should correct our
difficulties.
Approved For Release 2002/Qi RDP78-0282OA000400040046-3
Approved For Release 20021S'IA-RDP78-02820A000400040046-3
k. The Motorola 60 watt Base Station which was removed from
Room 2 has been taken to the Installation and Maintenance
25X1A6d Branch Shop,II Warehouse. We are in the process of
reconditioning the equipment, and modifying it for repeater
operation. It will then be taken to for installa-
t i n?
59 Because of the unfavorable weather the contractor has been
unable to install the second Y.H.F. antenna on the microwave
25X1A6d tower at
6. Preventive maintenance has been performed on seven Motorola
Handie-Talkie units for the Office of Security, 1412 "I" Building.
7. Specifications and drawings have been prepared for the
reconditioning of the 2Llon towers atop of East, North, and
Administration Buildings. We will not be able to submit the
plans to G.S.A. until after 5 January 1959.
C. KY-1 Voice Privacy System
1. Four trouble calls were received for this period. This is
encouraging, for the units appear to be reaching a relative
1ttroublefree" state,
2. The KY-i switchboard automatic register readings are as
follows.
NIC
28 November
to 23 December
1958
135 calls
SPS/AFB
28 November
to 23 December
1958
48 calls
DDI
28 November
to 23 December
1958
22 calls
DCI
28 November
to 23 December 1958
24 calls
A total of
1158 calls were counted for this period.
3. The KY-1 telephone booth has been removed from the DCO's office.
25X1A9a 4. has been given training on a time -available
basis, and he has progressed to a point where he can maintain the
KY-1 system. Of course, as he gains experience the time spent per
trouble call will be reduced, and in time he should develop into
a good KY-i technician.
?.T
Approved For Release 2002/05/01 : CIA-RDP78-02820A000400040046-3
Approved For Release 2002/05/O4tlL.t8 P78-02820A000400040046-3
D. AS-8 Equipment
11 This report summarized the AS-8 activities for the period
ending 29 December 1958. The installation was completed.
5 December 1958, and tests have been conducted since that
time,
a. As AS-8 installation report containing a summary
of the installation, and recommendations for its
future use has been completed. AnAS-8231D-20
modification instruction report containing the
information necessary to modify a 231D transmitter
for AS-8 operation, AS-4 operation or normal
operation is nearing completion.
b. The maintenance performed during this period was
minor. Two outages were caused by the field station
equipment, and one outage was caused by the base
station equipment. The field station troubles were
traced to a cold solder Joint in the communications
unit, and a defective diode in the power amplifier
units, Auto-tu*e system. The base station trouble
was found to be a defective diode in the printing
unit.
2.1 is being given informal training on a time-
available basis. A more formal training course is being
prepared for future use,
E. 6 ST Equipment
1. A complete inventory and an operational check of all equip-
ment except the generators was made of the transmitting and
receiving vans. All of the electronics equipment in the receiving
van is operational, with the exception of seven communications
receivers which need calibration or realignment. The fire
extinguishers and typewriters 1, 2, 3, 4 and 5 should be serviced.
The following equipment in the Transmitting van will need repair.
1.
2.
3.
4.
5.
Two TAC-1 Units
HT-4 Transmitter Number 1
One V.O.X.
One 51 J Receiver
One URT-11 Transmitter
Approved For Release 2002/05/0"IRIff P78-02820A000400040046-3
Approved For Release 2002/05 EC TRDP78-02820A000400040046-3
F. Special Projects
1. Completely installed G.E. 25 watt transmitter receiver in
two vehicles for SIB, Twenty-five watt G.E. Equipment has also
been mounted in another vehicle, but in this case 25 1A6d
the microphone, speaker, and make other modifications.
2. Repaired one 25 watt G.E. Transmitter. Receiver.
3. Repaired two RT-6 transmitters, and one RP-6 power supply for
the American Division.
4. Repaired one Bogen Amplifier, and one Motorola Conelrad
receiver for the Signal Center.
III MECHANICAL MAIFE ANCE SECTION
A. Preventative maintenance was performed on all emergency
power generators as scheduled each Friday.
B. Inspected twelve generators for the T&I section.
It Branch Supply
A. Requisitions and Property Turn Ins
1. Equipment ordered this month as requested by OC-E/I&MB is
as follows.
a. The Wire Maintenance Section requested three
par metal racks at a total cost of $100.62.
These racks are for the installation of KW--26's,
b. The Electronic Maintenance Section requested one
Output Meter, one Test Equipment Calibrator, and
four antenna coupling units at a total cost of
$439.44.
2. Six requisitions consisting of 69 line items were processed
for field shipment at a toatl cost of $551.05.
3. As of 23 December $19,641.17 has been expended for spare
parts required to maintain stock levels for equipment serviced
by OC E/I&ANB and to fill re, nests by the field stations.
4. One Model 15 Teletypew;ItAr Ent was transferred from
Account 180 to Account 9101 1
Approved For Release 2002/05/01~VX?)6?a4P78-02820A000400040046-3
Approved For Release 2002/05 DP78-02820A000400040046-3
5. Three Model 28 Teletypewriter Sets and seven Model 15
Consoles were transferred to warehouse stock.
Be Cryptographic Material and Equipment
1. One hundred and five new line items of spare parts at
a total cost of $1,068.23 were ordered for the modified KY-1.
2. Four each .HW-19A, Electronic Start-Stop Teletypewriter
Signal Mixers were transferred to Commo-Security Vault,
3. One IX-3 Facsimile Set was picked up from the Curie Hall
Vault by Commo-Secuirty for shipment to the field,
4. Six each Interconnecting Cables to be used with the XL-47
Electromechanical Literal Cipher Machine were ordered from
the Navy.
C. Other Activities
1. Flexowriter Parts Manual and a Description and Adjustment
Manual were ordered from Commercial Control Corporation.
2. At an Approximate cost of $2,508.70 (340) line items of
spare parts for the Model 28 ASR and Transmitter Distributor
were ordered. This brings the total of parts ordered for
the Model 28 equipment to 789 line items, approximate cost
$6,890.62.
3, Line Feed Counter
One line item was received this month, this brings the total
still due into three.
ADMINISTRATIVE
8 December 1958
3 December 1958
8 December 1958
Approved For Release 2002/05/01 : C'^.,- 18-02820A000400040046-3
SECRET
25X1A9a
L Approved For Release 2002/05/01 : CIA-RDP78-0282OA000400040046-3
Approved For Release 2002/05/01 : CIA-RDP78-0282OA000400040046-3