PROTOCOL OF THE SECOND MEETING OF THE CLEAN FUELS SUBGROUP OF THE US/USSR STATIONARY SOURCE AIR POLLUTION CONTROL TECHNOLOGY WORKING GROUP
Document Type:
Collection:
Document Number (FOIA) /ESDN (CREST):
CIA-RDP79-00798A000800030014-2
Release Decision:
RIPPUB
Original Classification:
K
Document Page Count:
32
Document Creation Date:
December 9, 2016
Document Release Date:
June 14, 2000
Sequence Number:
14
Case Number:
Publication Date:
December 18, 1974
Content Type:
MF
File:
Attachment | Size |
---|---|
![]() | 1.08 MB |
Body:
ed For Reftse 2000/09/06 : CIA-RDP79-00>A000800030014-2.~~
UNITED STATES ENVIRONMENTAL PROTECTION A :1 NC`!
R
DEC 1. 8 1974
OFFICE OF
RESEARCH AND DEVELOPMENT
MEMORANDUM FOR RAY PARDON
Office of Soviet Union Affairs
Department of State
SUBJECT: Protocol of the Second meeting of the Clean Fuels Subgroup
of the US/USSR Stationary Source Air Pollution Control
Technology Working Group
The enclosed subject Protocol is being transmitted to you for your
information. The agreement is the result of the Clean Fuels Task Force
meeting of the US/USSR Stationary Source Air Pollution Control Technology
Working Group.
Margaret J. Stasikowski
Technical Assistant
Air Pollution Control Division
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approved For Release 20N/09/06 : CIA-RDP79-00798AO0 0030014-2
u JAiv 1915
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
p . se 2000108/.4.6.: CIA-tAP79-00 Q.0080003001roved.ForRe.I :4-2
P R...O.1 O' C 'o
of the Second meeting of the Clean Fuels
Subgroup of the US/USSR Stationary Source
Air Pollution Control Technology Working
Group.
In accordance with the protocols of the second meeting of the US/USSR
Working Group on Stationary Source Air. Pollution Control Technology signed
in Washington, D. C. on April 25, 1974, and the protocol of the Particulate
Abatement Technology and Process Modification and Improvement subgroups signed
in Moscow on October 25, 1974, meetings were held in the USA between the US
and USSR delegations during December 1-13, 1974.
The U. S..delegation was headed by Mr. T. K. Janes, Chief of the Fuel
Process Section, Control Systems Laboratory, U. S. Environmental Protection
Agency. The USSR delegation was headed by Mr. V. M. Mas.lennikov, Laboratory
Chief, Institute of High Temperature, USSR Academy of Sciences. Participants
of these discussions are listed in Appendix 1.
The Soviet side was accorded an opportunity to visit several U. S.
organizations working in the areas of Pollution Control of the environment
by processes such as fuel gasification, liquefaction, fuel gas cleaning,
oil demetallization, coal preparation, and advance systems for generating
electrical energy from coal and oil. The Soviet delegation consisted of
representatives from the USSR Academy of Sciences, USSR Ministry of
Petroleum Refining Industry and USSR Ministry of Coal Industry. The air
pollution impact and control technology topics under discussion were related to:
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approved For Re se 2000/09/06 : CIA-R P79-OONMAOOO8OOO3OO14-2
A-7 Demetallization Pretreatr:.ent, for Ilydroclesulfur.ization of
Heavy Residual Oils
yv' B-5 Gasification of Coal and, Oil and Cleaning of Fuel
Gases for Power Generation
B-6 Production of Liquid Fuels from Coal and Mixtures of Coal-Oil
B-7 Improvement of Equipment and Technology for Coal Enrichment
B-l0 Development of Cormnon Methodology for Comparing the Economics
of Various Processes for Hydrodesulfurization of Heavy
? Petroleum Stock
B-il Power generation plant with combined cycle based on
gasification of Coal and 0.1
B-12 Gas Cleaning Systems for Coal and Oil Gasification Systems
B-1 Design and. Operations of Industrial Coal and'Oil Combined,
Cycle Plants.
A list of facilities visited is attached in Appendix 2.
The detailed schedule and work plan for project A-7 identified in the
2nd protocol for the "Demetallization Pretreatment for'llydrodesulfurization.
of Heavy Residual Oils to Produce Low Sulfur, Low Ash Fuel Oils" were
finalized during this meeting. Included in this discussion, would be
methods to improve desulfurization of residual oil. The details are given
in Appendix 3. After successful completion of the Project, as outlined
in the work plan, both sides agreed to discuss prior to the end of 1975 the
possibility of additional programs in this area.
Approved For Release 2000/09/06: CIA-RDP79-00798AO00800030014-2
-Approved For Reuse 2000/09/06..: CIA-RD.P79-O'98AQQ0.8:0003001:4=2~,
The B category projects B-7, B-10, B-11, B-12, and B-13 were
reviewed, modified and finalized for submission to the work group for
approval. The details of the modified projects are shown in. Appendix 4.
The technologies covered under Projects B-5 and B-6 were discussed and the
following was agreed. Both sides agreed that the technology covered in
B-5 and B-6, gasification of coal and mixtures of coal and oil could not
be discussed in detail. Additionally both sides recognized that other
US/USSR groups are interested in these areas. however, LL L~, ai.0-
that each group would be stressing different aspects of the technology.
Details of these projects are shown in Appendix 5. The U. S. side expressed
an interest in cooperation in the areas of identification and control of
environmental impact from oil shale processing and? slurry. combustion. The
U. S. side additionally felt that the situation is quite similar to the
above situation on coal gasification and liquification and recommends a
similar approach. Both sides recommend that each coordinate with the
various groups and interested factors on
necessity of having a meeting of experts
meeting to further develop possibilities
The subgroup recommends these topics be
meeting in 1975. Both sides agree that
status of work and agreed to the
prior to the next working group
for cooperation in these areas.
discussed at the next working group
to increase the. fruitfulness of the
cooperation, at the conclusion of each meeting unresolved questions will
be formulated and program outlined that would develop the necessary
information for discussion at the next meeting.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
MR. T. K. JANES
Head of the U.S. Delegation
in the Working Group
Chief, Fuel Process Section
U. S. Environmental Protection
Both sides noted the meetings were conducted in the spirit of
friendship, mutual understanding and cooperation.
The protocol was signed on December 13, 1974, in Washington, D. C.,
in Russian and English, both texts being equally authentic.
For the U.S.S.R. Delegation
Agency
.:4. W.. DEURBROUCK
Research Supervisor
U. S. Bureau of Mines
F. ~'. C1~IORA
Vice President, Institute of
Gas Technology
,
Senior Research Worker of
VNIINP, USSR Ministry of
Petroleum Chemistry and
Petroleum Refining Industries
MR YU. K. VAYL
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
MR. V. M. MASLENNIKOV
Head of the USSR Delegation
in the Working Group
Laboratory Chief of IVT of
the USSR Academy of Sciences
4S.,' YE.GORCOV...;.
Deputy Director of IOTT, USSR
Ministry of Coal Industries
Approved FQr elease 2000/09% 6' :'CIA-RDP7 )798A0008,0QQ,30O14-2 .
Approved For .Reese 2000109/06.:. CL -RDP79-00`1"A0p:0800'0.30014-2
APPENDIX I
Delegates and experts, participants of the 4th
working meetings of the US/USSR subgroup on
subjects of Clean Fuels
U. S. S. R.
MR. V. H. MASLEI''INIKOV
MR. N.' S." YEGOROV
112- Y..-U..K VAYL
U. S. A.
MR. T. K. JANES
MR. A#, W..DEURI3ROUCK
MR. FRANK SCHORA
DR. DAVID ARCHER
DR. FRED ROBSON
DR. R. A. MEYERS
MR. G. R. SMITHSON
DR. CLARENCE JOHNSON
MR. W. J. RHODES
Laboratory Chief of IVT of the
Academy of Sciences
Deputy Director of IOTT of the
Ministry of Coal Industries
Senior Researcher of VNIINP of the
Ministry of Petroleum Industries
Chief, Fuel Process Section,
U. S. Environmental Protection Agency
Research `Supervisor p?i ttsburgh
"'Research Center, U. '' S. Bu're6u 'of:Miines'
Vice President, Institute of Gas
Technology
Manager of Chemical Engineering,
Westinghouse Research Laboratories
Chief, Utility Power System,
United Aircraft Research Laboratories
Manager of Coal Desulfurization,
TRW Systems and Energy
Manager, Environmental Programs,
Battelle Columbus Laboratories
Senior Vice President,
Hydrocarbon Research, Inc.
Project Engineer, U. S. Environmental
Protection Agency
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
MR. JAMES KTJ-C,ROC
MR. LLOYD LORENZI
MR. J. NOTARY
MIEZ. J. DRAPER
14R. E. CARROL
MR. R. BUZONAS
MR. E.t SARAPUKA
DR. KAMM
DR. B. L. CRYNESS
Project Engineer, U. S. Environmental
Agency
Project Engineer, U. S. Environmental
Agency
Vice President
Heyl, and Patterson'
Superintendent, Warwick Preparation Plant
Drevo Corporation
Superintendent, Banning Preparation Plant
Scientist, Illinois Geological Survey
President, Oklahoma State University
Professor of Chemical Engineering
Oklahoma State University
Professor of. Electr4.cal Enoinoeri..
Oklahoma State University
Professor of Mechanical Engineering
Oklahoma State University
DR. H. J..ALLI.SON
DR. R. J. SCHOEPPEL
Mrs. Catherine Guilsher - Interpreter
Mr. Vladimir Storojen - Interpreter
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approved- For Release. 2000/09/06 CIA-RDP79-00798A00080003:0014-2
Facilities Visited by the USSR Delegation
1. Westinghouse Research Laboratories, Pittsburgh, Pennsylvania
2. Bituminous Coal. Research, Inc., Monroeville, Pennsylvania
3. U. S. Bureau of Mines, Morgantown, Pennsylvania
4. U. S. Bureau of Mines, Briceton, Pennsylvania
5. Hydrocarbon Research, Inc., Trenton, New Jersey
6.." Heyl and Patterson, Pittsburgh, Pennsylvania
7. Duquensne Light Co., Warwick Coal Preparation Plant,
Greensboro, Pennsylvania
8. Republic Steel Company, Banning No. 4 Coal Preparation Plant,
Van Meter, Pennsylvania
9. Institute of Gas Technology, Chicago, Illinois
10. UOP, Des Plaines, Illinois
11. Oklahoma State University, Stillwater, Oklahoma
12. City Service Refinery, Lake Charles, Louisiana
13. EPA, Waterside Mall, Washington, D. C.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Apprpved.For Rase 2000/09106 GIA-IRDP79-0t 8Ap00800:0300.14-2
Apj~endi x 3
Project A-7: Demetallization Pretreatment for Hydrodesulfurization of Heavy
Residual Oils to Produce Low Sulfur, Low Ash Fuel Oils
At the meeting, tests and schedules have been discussed for Project A-7.
Both sides have agreed that two types of dem6tallization runs will be con-
-ducted. The first type is called screening tests and the second type is
called long duration runs. The tests to be performed in the United States
are shown in Table 1. The tests to be performed in the USSR are shown in
Table 2. Also shown are other pertinent data. The conditions are shown in
Table 3.
The main purpose of the screening tests is to determine if results already
available in each Country can be reasonably well reproduced in the other.
Country. This will indicate that differences in test equipment,' procedures,
and other undefined differences do or do not affect the results. Additionally,
these tests provide a relatively inexpensive and timely way of evaluating
materials, test and analytical procedures, test conditions, etc., that are
unfamiliar to each side. These tests will also provide some background data
for use in subsequent long duration tests.
The long duration tests are designed to provide sufficient demetallization
data on catalyst and oils so that each Country will have a good knowledge of
the state-of-the-art in the other Country and the relative advantages and
disadvantages of each test combination. The length of the tests was selected
with this in mind. Also, the test duration will produce sufficient demetallized
feed to allow subsequent desulfurization tests of 20 to 25 days, if the data
deinctallization is satisfactory.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
roves.ror Kelease zvvyiuyiub :'c:iH=KUI-Itl-UUI AUUUt$UUUJUU 14-1
The test run conditions were selected on the basis of each Country's
experience with the respective oils. If during screening tests or long
duration tests either Country finds that these conditions are unsatisfactory,
they will, notify the other Country of the situation and an attempt to arrive
at more acceptable test conditions will be made.
Upon completion of the screening tests, the results will be exchanged
and, if no problems were encountered, only a minimum of data review time
will be utilized. After the review, the long duration runs will be initiated.
The target test schedules are shown in Table 4 with the actual starting date
being mainly determined by receipt of all necessary materials.
For each run that is conducted a?series of analyses will be performed
as shown in Table 5 and demetallized product samples exchanged. All materials
to be exchanged are shown in Tables 6 and 7.
After completion of these tests and exchange of data, a final report,
that is co-authored by both sides will be prepared. This report will describe
the work and results of these investigations.
Either during or after the long duration tests further communications
regarding additional tests will be entered into.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
pp;rou~d :F ::R,el a 0OjQB/4f . GjA-.QP-7 .. ,7-_
Tests in the United States
I. Screening tests - 100 to 150 hours duration
II.' Long Duration Tests
Catalyst Oil
U.S.S.R. (2% MoO3) U.S.S.R. atmospheric resid
500 hours duration
Run No.
Catalyst
Oil
'1
U.S.S.R. (2% t"1o03)
U.S.S.R. atmospheric resid
2
U.S.S.R. vacuum resid
3
U.S.A. vacuum resid (Tia Juana)
4
U.S.A. (1% Mo)
U.S.S.R. atmospheric resid
5
U.S.S.R. vacuum resid
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
i
pr.Qved',FG Re! se OQO/0 /06 CI -RDP79 OO7'9 AO0{~80OO3QO14- :
P- W,
I.? Screening Tests - 100 to 150 hours duration
II. Long Duration Tests
Run No.
Catalyst
Oil
U.S.A. (1% Mo) U.S.A. vacuum resid (Tia Juana)
U.S.A.-vacuum resid (Gach Saran)
- 500 hours duration
Cata,l yst Oil
U.S.A. (1% MMo) U.S.A. vacuum resid (Tia Juana)
It U.S.S.R. vacuum resid
U.S.S.R. (2% MoO3) U.S.A. vacuum resid (Tia Juana)
U.S.A. (0% Mo) U.S.S.R. atmospheric resid
U.S.S.R. (2% MoO3) U.S.A. vacuum resid (each Saran)
Approved For Release 2000/09/06 : CIA-RDP79-00798AO00800030014-2
;CIA-RDP79-QO A000~00030014=
. proved...For Rel s.e 2000/.09/06
Target Test Conditions
For aWospheriic: f'esid:
Temperature = 400?C
Space Velocity = 1.0
Hydrogen partial pressure = 2000 psig (2050 psig total)
For vacuum resid:
Temperature = 422?C
Space Velocity = 0.75
Hydrogen partial pressure = 2000 psig (2050 psig total)
Test Equipment:
Each Country to use their respective equipment
corresponding to approximatej'y a 200 cc reactor
Volume of catalyst
Approved For Release 2000/09/0,6 : CIA-RDP79-00798A000800030014-2
Approved. For Re se 2000109/06: CIA-RQP79-00 A000800030014-2
Target Schedules
Tasks ype of Activity.
1. Transfer of all necessary
materials, shipping date
2. Complete screening tests
3.
Exchange information on screening
"tests
4. Long term tests
Duration 'and/or Date
January 31, 1975,
shipping date
1 month after actual
item 1 date
1/2 month after actual
item 2 completion
After cormpl eti on of it,,-,m 3
initiate approximately 1 test
per month. However, July 31 , 1975,
is a target completion
5. Complete and exchange
draft report
6. Meeting in the U.S.S.R. to
discuss drafts, outline of final
report and responsibilities
In its preparation, and discuss
additional tests
7. Prepare final drafts and
exchange them
8. Meeting in U.S.A. to prepare
co-authored final report
and possible articles for
publication
9. Conduct communications regarding
additional work (demetallization,
desulfurization or other tests).
1 month after actual completion
.of item 4
1 month after draft exchange of
item 5
1 month after meeting of -item 6
1 month after exchange of Final
drafts
Initiate during or after long term
tests depending on test results.
Approved For Release 2000/09/06: CIA-RDP79-00798A000800030014-2
Approved For ReMse- 2000/09/06 CIA-RDP79-00MA000800030014-2
Table 5
Samples and Analyses
I. For All Test Runs
I. Samples
A. Feed material
B. Detnetail.ized product at 50 hours into test run
C. Demetallized product at end of test run
D. Used catalyst
2. Analyses on oils from 1 above
A. Specific gravity
B. Metal content (V and Ni)
C. Sulfur analysis of liquid products, C4+
D. Sulfur analysis on vacuum distillation fraction
IP - 500?C
500?C
3. Analyses on used catalyst
A. C %
B. S %
C. V ppm
D. Ni ppm
Additional Analyses for Long Duration Tests
Bulk density, surface area, pore volume,
and pore size distribution on
used catalyst and on fresh catalyst
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approved For.Rele'e'2000/09/06 :: CIA-RDP79'-007 000800030014-2
U.S.A. Materials to. be sent to the U.S.S.R.
I. Screening Tests
A. Supply for the runs
1. one drum (55 gallon) of Tia Juana vacuum resl,d
2. one-.half drum of Gach Saran vacuum resid
-3. one liter of promoted catalyst (1% Mo)
B. Obtained from the tests
1. 20 grams of used catalyst (USSR 2% MoO3) from screening tests
2. one-half liter of dcmetallized product at 50 hours
3. one-half liter of dcmetallized product at end of run
II. Long Duration Tests
A. Supply for the' runs
1. three drums (55 gallons each) of U.S.A. vacuum resid (Tia Juana)
2. two liters of promoted catalyst (1% Mo)
3. one liter of unpromoted catalyst (0% Mo)
4. one-half drum of U.S.A. vacuum resid (Gash Saran)
5. one drum of U.S.A. vacuum resid (Tia Juana if available
alternate Bachaquero)
B. 1. 20 grams of used catalyst from each run
2. one-half liter of demetallized product at 50 hours
3. one-half drum of U.S.A. vacuum resid (Cach Saran)
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Table 7
U.S.S.R. Materials, to be sent to the U.S.A.
A. Supply for all runs (total for screening and long duration)
1. three drums (200 liters each) of USSR atmospheric Tesid
2. three drums (200 liters each) of USSR vacuum resid
3. two liters of USSR catalyst (2% MoO3) sized to 20X50 mesh.
B. Obtained from the tests
1. 20 grams of used catalyst from each run
2. one-half liter of Cdemiietallized product at 50 hours for each run
3. one-half liter of demetallized product at the end of each run.
Approved,For R? ase 200G/O9/06 : *C.IA-RDP79 O 8A00080Y0030Crl4-2.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Appro"ved For Rase 2000/09/06 :CIA-RDP7.9-0
98 AOQ0$.0003.00,14:-2
Project B-7: l.mprovC,flent of Ec;uipmcnL and Technology for. Coal Erin ichic::%rit
1. Background
In USSR and USA the flotation of coal. is widely developed. However, the
trends in development of equipment and technology in both countries have nut
been analogous, Research on the desulfurizartion of coal by flotation is also
ongoing in both countries.
As a result, the flowsheets, equipment, the quality of the finished pro-
ducts,'and methods of handling the flotation concentrates and tailings are
different in the two countries.
2. Objective
i
Development of optimum methods for the design of equipment and improved
technology of desulfurization of coal. by flotation processes.
3. Scope of Work
The following tasks will be performed to achieve the above objectives.
.Task I:
Exchange of detailed information on the following:,
a) Results of research on desulfurization of coal. by flotation.
b) Flowsheets, equipment, and quality and quantity indicators of
the desulfurizati.on of coal by flotation products including
characteristics of raw coal., anxiliary equipment, flotation
reagents and methods for handling flotation products.
c) Results of research on optimization of flotation equipment.
The information and data to be exchanged will be transmitted in the form
of concise written reports on flotation equipment design and technology of
coal desulfur.i.zation by flotation.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approve
Expert, from both countries will meet for evaluation of the inforr;ahi.on
received and development of the program for further cooperation.
Task III:
Experts from both countries will meet to develop a methodology for joint
studies and exchange samples of coal, flotation reagents, and technical
schemes for desulfurization of coal by froth flotation.
1E. Task I - July 1975
Task II - Third quarter of 1975 we will meet in the USSR
Task III - Fourth quarter of 1975 we will meet in the USA
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approved, For' P, We se 2000/09/06: C1A-RDP79-0Q7 8A000800030014-2.
B-10: Development of Common Methodology for Comparing the Economics
of Various Processes for Hydrodcsulffuriza'Lion of Heavy Petroleum Stock
1. Background
Discussions were held at VNII NP to define specific opportunities for
cooperation in the field of economic evaluation of approaches to sulfur
oxide control which are not affected by the proprietary nature of information
in the economics of petroleum refining in the U.S. Reports illustrating the
general nature of work in respective countries were exchanged.
2. Objective
To develop methods for comparing SO2 control process econowd cs i n the
US and the USSR.
3.. . Scppe of Wo,r k
Task I
Both sides will review materials supplied and consider possibilities for
joint work. Both sides are to make a discussion and transmit the answer.
Task II
If cooperative possibilities are identified a meeting between experts
from the US and the USSR will take place in the US. If agreement is reached
experts will prepare a proposed project for consideration at the Working Group
at its next meeting in the first quarter of 1975.
4. Schedule:
Task I - January 15, 1974
.Task II Prior to Working Group meeting, Moscow, April 1975.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
13-?1.1: Power generation plant with combined cycle based on gasi_ficati.on:i
". Apia roved F.or'Re ase 2000/0'9/06.':. CIA-RDP79-00 AOOn*80OO300144-2
I. Background
Oil and coal combined--cycle power generation systems are at interest to
both the US and the USSR. The purification) of the products of gasification
and combustion is of major importance to both long-teem operation of the poser
generation system and for environmental protection. ?
2. Objective
It is the objective of this effort to jointly select the best integrated
gasification, clean up and combined-cycle power plant system and to prepare
preliminary designs of these selected combinations which would form the basis
for additional effort that could result in the design of a full scale plant.
I. Scope of Work
Task I
Information will be exchanged that would present the best power generation
with,combined cycle'concepts in both countries. This information should be
concise and conceptual in technical details and will 'include the following:
-- Cycle configurations, coal/oil gasification, fuel gas clean up
and power generation consisting of flow diagrams, operating
parameters and material balances. Configurations will bc identified
as either base, intermediate on peak loading type operation s.
-- The basis and philosophy behind the design selection will be discussed
-- Cost of the electrical and thermal. energy will be presented and
consideration will be given to, effects of variations in configuration
and in plant capacity on the cost. Since the technology being
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approved For Re1ase?2000/09/06 , CIA-RDP79-0d 8A0p0800.03001'4-2'-'
presented i s coneenl.ual and prcl. i m:rinary In nature the cost:
comparison should be made by iocii.cating effects by percentage
decrease or increase in the cost of electrical and thermal energy
instead of absolute values.
--- To provide for a basis of comparison both sides will present
a cost analysis of a conventional coal/oil fired power plant.
This plant should include emission control and consist of five (5),
500 megawatts steam power units (540OC, 1.60 atm).
-- A concise the-state-of-art of the integrated combined cycle power
generation technology in both countries will be prepared. Included
will be a list of all combined cycle installations.
Task II
One month ;after the. exchange of information described in Task. I has been
completed, a meeting will be held to discuss the exchanged information. The
proceeding discussions and results of this meeting will be presented in a
report jointly prepared by both sides and will be published in both countries.
Task III
Based on the results, information and program defined in Task II, on the
best conceptual designs of an integrated oil and coal gasification,'clean up
and combined cycle power plants, both sides will conduct engineering studies
of these selected (1 or 2 configurations by.each side). The studies would
address the technology, economics and operating conditions to a level that would
be a basis for an engineering design of a commercial operations. The results
of these studies will be exchanged by both sides.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
One month after the exchanged material has been received, both sides
will meet to discuss and review the, information. The result of the enginecr~.
evaluation (Task IV) will be used' to identify the best one or two designs
for a comnmercial. integrated coal and oil. gasification, clean up and combined
cycle power plant. During this meeting , f%irther cooperative effort and
programs will be determined. The results of this meeting will be jointly
written summarizing the results and recommendations of the group and
included in the results from Task I through Task IV.
The results of the parametric studies will he used to identify the
best one or two conceptual designs for integrated oil gasification, clean
up and combined--cycle power plants and the best one or two conceptual designs
for integrated coal gasification, clean up and combined cycle plants which
would be used as the basis for study for future cooperation.
The report will define future work which would fulfill the intent of
this project which is to result in the best design of a commercial plant.
At that time, the working group will define the future program.
3. Schedule
Experts from the US and USSR will meet in the U. S. prior to the third
working group meeting. If the project is finalized and approved by the
working group, the following tentative schedule is projected:
Task I - 4 months
Task II - 6 months
Task III - 12 months
Task IV - 14 months
Approved For Re ease-.2000/09106 .: CIA-RDP79-00 8A00080-0.0-30014-2
Task IV,..
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approved For Rel se 2000/09/06: CIA-RDP79-001 Ab008-0003O01'4-2
Both sides feel Lha1_ Task I and 'Cask 17: could be co;;plcted in the
first half of 1975, since this work is already being conducted. AddiCion 11y,
the develof>;ncnt of the joint reports will. be done concurrently with tl:C
studies.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
pproved. Fnr?-Rel se-2GOQIO9/d6.~. CIA-RDP79-QO AOMiRn 3OO14-2..
6-12: Gas Cleaning Systems for Coal and Oil Gasific,:i:ion Systems
Gas Cleaning Systems for the Coal and the Oil Gasification used in Power
Generation Plants.
1. Background
Both the US and the USSR are develo;:ing gas cleaning = des ulfun atien
and particle removal - systems adapted to use in fuel gasification for power
generation plants. These systems produce a clean gaseous fuel either for a
steam boiler or for a gas turbine combustor. Various processes produce the
fuel gas at temperatures from 500 ?C (900?F) to 1500?C (2700?F) and at
pressures from 1 atm to 30 atm. Similarly, various gas cleaning processes
operate at temperatures from 60?C (150?F) to 1000?C (1800?F) and at pressures
from 1 atm to 30 atm. If a low temperature cleaning system is employed, a
meads for cooling the fuel gas is required; means for recovering its thermal
energy may also be required. Practical low temperature gas cleaning systems
are based on scrubbing with aqueous solutions. High temperature desulfurization
based on solid sorbents limestone/dolimite, iron oxide, manganese oxide,
etc. - and departicularization based on cyclones and granular filters have been
studied in both the US and the USSR.
2. Objectives
The objective of the work is to identify the most promising gas cleaning
systems for fuel gasification power generation plants and to recommend a
program which will complete the development and first full scale operation of
such systems.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approved. FQr Rd
Vase 2000/09106.:- CIA-RDP79.-00 .8A000,800030014=2.
3. Scope of Work
Task I
Data to be used jr, the wort; will be asSCMblcd by responsible
organizations in the US and the. USSR. Information exchmigcd describing the
systems -- flow diagrams operating conditions, material and energy balances,
performance, and the state of develop!-,cont., The advantages and d:LS~:I.J nt:~ ges
of each system will be discussed. Data would also address the relative
economics of each concept.
Task II
One month after exchanged material has been received, a meeting will
be held to discuss the exchanged material. All. material. must be received
from both sides one month prior to the meeting.
Task III
Selection of z preferred or best gas cleaning systems - one for'
operation at low temperature and-one for operation at high temperature will
be made by the US and by the USSR. These selctions will be made based on
estimates of performance and economics. The data and methods for evaluating
the systems will be shared, unless previously established proprietary rights
prevent such sharing. Both the technology and philosophy of the evaluation
process will be discussed.
Task IV
The results of the work will be presented in a joint final report. This
document will not only summarize work accomplished results achieved, and
conclusions, reached, it will recommend further studies, laboratory work,
pilot plant investigations and demonstration efforts to achieve successful
cleaning systems for fuel gasification power plants.
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
pproved.-F.0 r, I p( as ..2000109106.:.:. CIA,-F P79,OO AO0080003001, -2.
At the *nc_eting, ha:.,ed on the best high and low temperature cl.e?ui.t. ,
systems as chosen by each side, the technology, engineering design,
economics, measurement technique and status of work will be discussed.
Based on the discussions, recommendations will. be made as to further
project work.
4. Schedule
If project is finalized and approved by the Working Group the
following schedule is projected.
Task I - 2nd Q 75
Task II - 4th Q 75
Task III 2nd Q 76
Task IV - 4th Q 76
Approved For Release 2000/09/06 : CIA-RDP79-00798A000800030014-2
Approved For RbWase 2000/09/06 CIA-RDP79-O J8A000800030014-2
`iL
13 t 1 , ) , . ti a l l Opel?'c:i, of : rci.al . Ca .l.' or '01.A.- C as ient:.i~I : or '
1. Background
At the present time utility application of coal and oi.l gasification for
power generation plants are being considered by investigators in the US and USSR.
These plants are now being designed without the aid of mutual couper: